Thread Rating:
  • 0 Vote(s) - 0 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Heater Core!
#2
(10-18-2012, 09:12 AM)Gravter Wrote: Well, I'm not sure if it's really it, but I think my heater core is leaking!
My windows fog up on the inside but I can't really smell anything. I don't see any leaks in the cabin either. Anything else I should check?
How hard or EASY is it to change the heater core? I'm hoping it won't require me to take it to the shop. I've changed one in my old '83 Mustang years ago.

Thanks for your help!

The fogging up certainly suggests water/moisture in the cabin, but IIRC a leaking heater core would dump coolant which you would definitely smell. Do you have any leaks into the cabin - perhaps a wet smell after a car wash or rain? Do you sweat profusely LOL?

Replacing is by my standards definitely a DIY job - but according to the manual it looks to be a few hours.

  1. Drain coolant
    Using the special tool, disconnect the coolant hoses from the heater core
    Remove the floor console
    Remove the rear footwell vent air ducts
    Remove the footwell lower trim panel
    Open the glove compartment.
    Remove the footwell vent air duct; Pull off the hose.
    Close the glove compartment; Remove the footwell trim; Remove the left-hand and right-hand retaining screws
    Remove the accelerator pedal; Disconnect the electrical connector
    Detach the rear steel clip NOTE: Take care not to damage the seat when detaching the clip
    Remove the left-hand and right-hand in-vehicle crossbeam bracket
    Remove the heater core air duct housing
    Remove the heater core retaining bolt.
    Remove the heater core


2008 Fusion SEL MTX - DD1 * 2009 Fusion SEL - DD2 * 2007 Focus ZXW - R*I*P * 2004 Focus ZTW CD Silver - sold * 2004 Focus ZTW Black - sold * 2003 Focus ZTW Black - sold * 2001 Focus ZTW Gold - sold * 2000 Focus SE Wagon (ZTW option) - Black - sold * 2000 Focus SE Wagon (ZTW option) - Gold R*I*P

2003 Focus ZX5 infra-red Track Rat - R*I*P
2003 ZX5 CD Silver Track Rat - retired, but still in the driveway


New track rat: 2000 ZX3, Atlantic Blue * JRSC with lots more to come

* New Zetec crate motor - NFG - thanks Topspeed *
Reply


Messages In This Thread
Heater Core! - Gravter - 10-18-2012, 09:12 AM
RE: Heater Core! - ZTWsquared - 10-18-2012, 09:44 PM
RE: Heater Core! - Gravter - 10-19-2012, 12:40 AM
RE: Heater Core! - Lucster1000 - 10-19-2012, 01:56 AM
RE: Heater Core! - GFXjamie - 10-19-2012, 05:59 AM
RE: Heater Core! - reldridge - 10-19-2012, 11:55 AM
RE: Heater Core! - Gravter - 10-21-2012, 03:25 AM
RE: Heater Core! - Gravter - 11-26-2012, 01:59 AM
RE: Heater Core! - ZTWsquared - 11-26-2012, 11:53 AM

Forum Jump:


Users browsing this thread: 1 Guest(s)